Whelen M4B6R User Manual download pdf

Page 1

Installation Guide:

M4 LED Motorcycle Power Box

ENGINEERING COMPANY INC.

51 Winthrop Road

Chester, Connecticut 06412-0684

Phone: (860) 526-9504

Fax: (860) 526-4078

Internet: www.whelen.com

Sales e-mail: autosale@whelen.com

Canadian Sales e-mail: canadiansales@whelen.com

Customer Service e-mail: custserv@whelen.com

Automotive: Miscellaneous

Safety First

This document provides all the necessary information to allow your Whelen product to be properly and safely installed.

Before beginning the installation and/or operation of your new product, the installation technician and operator must

read this manual completely. Important information is contained herein that could prevent serious injury or damage.

• Proper installation of this product requires the installer to have a good understanding of automotive electronics,

systems and procedures.

• If mounting this product requires drilling holes, the installer MUST be sure that no vehicle components or other

vital parts could be damaged by the drilling process. Check both sides of the mounting surface before drilling

begins. Also de-burr the holes and remove any metal shards or remnants. Install grommets into all wire passage

holes.

• If this manual states that this product may be mounted with suction cups, magnets, tape or Velcro®, clean the

mounting surface with a 50/50 mix of isopropyl alcohol and water and dry thoroughly.

• Do not install this product or route any wires in the deployment area of your air bag. Equipment mounted or

located in the air bag deployment area will damage or reduce the effectiveness of the air bag, or become a

projectile that could cause serious personal injury or death. Refer to your vehicle owner’s manual for the air bag

deployment area. The User/Installer assumes full responsibility to determine proper mounting location, based on

providing ultimate safety to all passengers inside the vehicle.

• For this product to operate at optimum efficiency, a good electrical connection to chassis ground must be made.

The recommended procedure requires the product ground wire to be connected directly to the NEGATIVE (-)

battery post.

• If this product uses a remote device to activate or control this product, make sure that this control is located in an

area that allows both the vehicle and the control to be operated safely in any driving condition.

• Do not attempt to activate or control this device in a hazardous driving situation.

• If this product contains strobe light(s), halogen light(s) or high-intensity LEDs, do not stare directly into these

lights at a close distance. Momentary blindness and/or eye damage could result.

• If this product contains strobe light(s), halogen light(s) or high-intensity LEDs, use only soap and water to clean

the lamp lens. Use of other chemicals could result in premature lens cracking (crazing) and discoloration. Lenses

in this condition have significantly reduced effectiveness and should be replaced immediately. Inspect and

operate this product regularly to confirm its proper operation and mounting condition. Do not use a pressure

washer to clean this product.

• It is recommended that these instructions be stored in a safe place and referred to when performing maintenance

and/or reinstallation of this product.

• FAILURE TO FOLLOW THESE SAFETY PRECAUTIONS AND INSTRUCTIONS COULD RESULT IN DAMAGE TO

THE PRODUCT OR VEHICLE AND/OR SERIOUS INJURY TO YOU AND YOUR PASSENGERS!

Form No.14429 (101410)

For warranty information regarding this product, visit www.whelen.com/warranty

1 2 3

Summary of Contents

Page 1 - Automotive: Miscellaneous

Page 1Installation Guide:M4 LED Motorcycle Power Box®ENGINEERING COMPANY INC.51 Winthrop RoadChester, Connecticut 06412-0684Phone: (860) 526-9504Fax:

Page 2 - Operation:

Page 2Mounting Hole Locations4.75”6.37”6.37”10”5”5”CL1/4-20 x 3/4” Hex Head BoltFlat WasherInternal Tooth LockwasherPower Box (bottom)Vibration Dampen

Page 3 - Optional Equipment:

Page 3CHARGERPOWER CONNECTORCHARGER INLET15A/120 VACPOWERCONNECTORPOWERCONNECTORBUTT SPLICEFUSE BLOCK40 AMP FUSECUSTOMERSUPPLIEDFUSE BLOCK3 AMP FUSEWI

Related models: M4B6L | M4B6B |

Comments to this Manuals

No comments

Whelen M4B6R User Manual

Browse online or download User Manual for For the car Whelen M4B6R. Whelen M4B6R User Manual

Summary of Contents

Related models: M4B6L | M4B6B |

Comments to this Manuals

Related products and manuals for For the car Whelen M4B6R